Notice: Support Requests - Going forward, all support requests will be handled via the forum. Please see the help section.

FAQ

Contains Frequently Asked Questions relating to Engines, Transmission and Exhausts.

Followers

post your mk2 weber install pics please
post your mk2 weber install pics please
steveo3002, 25 October, 200718 yr
- 190 replies
- 71k views
sven01001

1 September, 201610 yr
Electronic Ignition on polos without it. FAQ.
Electronic Ignition on polos without it. FAQ.
Gaz, 11 October, 200520 yr
- 31 replies
- 18.4k views
v3ast

29 January, 201610 yr
lower temp thermostat
lower temp thermostat

StinkyPete, 6 October, 201114 yr
- 19 replies
- 4.5k views
MikeyMK

19 November, 201510 yr
Fitting a different cam to your 8v engine. (GT cam covered)
Fitting a different cam to your 8v engine. (GT cam covered)
MaxGT, 15 October, 201015 yr
- 100 replies
- 45.9k views
sven01001

11 November, 201510 yr
Fuelling your bike carbs
Fuelling your bike carbs
harris.racing, 19 August, 201214 yr
- 134 replies
- 18.1k views
dvderlm

29 September, 201510 yr
AFH 1.4 ->1.6 16v Bottom end conversion
AFH 1.4 ->1.6 16v Bottom end conversion
grungeisdead, 13 September, 201016 yr
- 281 replies
- 76.2k views
80sbreadvan

26 September, 201510 yr
Oil advice and recommendations here
Oil advice and recommendations here
oilman, 21 August, 200818 yr
- 132 replies
- 63.1k views
oilman

13 July, 201511 yr
1990 - 1994 Haynes Manual
1990 - 1994 Haynes Manual

Guest dan113, 23 July, 200818 yr
- 17 replies
- 12.7k views
JoeUK

2 May, 201511 yr
Polo 6n Over\Under Heating Cause and Solution.
Polo 6n Over\Under Heating Cause and Solution.
Q86ARR, 5 July, 200917 yr
- 31 replies
- 22.4k views
Connorphim

16 April, 201511 yr
Common Polo Problems mk1-mk3 (and solutions hopefully!)
Common Polo Problems mk1-mk3 (and solutions hopefully!)
Gaz, 4 January, 200620 yr
- 40 replies
- 45.1k views
hillmanie

7 April, 201511 yr
Weber DMTL/DMTR set-ups thread...
Weber DMTL/DMTR set-ups thread...
MaxGT, 30 June, 201115 yr
- 94 replies
- 21.3k views
Breadvan Princess

31 December, 201411 yr
How to: Replace the distributor Hall Sender
How to: Replace the distributor Hall Sender

Purple Tom, 22 December, 200718 yr
- 18 replies
- 22.9k views
allanmnz

19 October, 201411 yr
AAV Turbo conversion (useful for G40 turbo too)
AAV Turbo conversion (useful for G40 turbo too)
cheys03, 26 January, 201214 yr
- 31 replies
- 21.4k views
8volly

11 September, 201412 yr
filling gearbox oil??
filling gearbox oil??
Leggy, 17 February, 200620 yr
- 38 replies
- 20.8k views
funkster

14 June, 201412 yr
Golf VR6 TPS on a GT
Golf VR6 TPS on a GT

derskine, 29 October, 201312 yr
- 9 replies
- 3.6k views
derskine

6 May, 201412 yr
Mk4/5 1.4 16V Irratic Idle and Cutting Out
Mk4/5 1.4 16V Irratic Idle and Cutting Out
Robin, 17 January, 200719 yr
- 35 replies
- 63.3k views
whittaker92

30 April, 201412 yr
DIY Mk2/3 rear exhaust hanger replacement guide.
DIY Mk2/3 rear exhaust hanger replacement guide.
genesisGT, 9 November, 200817 yr
- 33 replies
- 18.3k views
~~K03~~

1 April, 201412 yr
Bike Carb Setup - Guide/Discussion
Bike Carb Setup - Guide/Discussion

harris.racing, 28 July, 201313 yr
- 2 replies
- 4.5k views
mattieboi6n

22 March, 201412 yr
Does your GT have the right dizzy?
Does your GT have the right dizzy?
Gaz, 31 October, 200520 yr
- 115 replies
- 42.6k views
joacomendez17

5 February, 201412 yr
Pre-1985 Polo's Ignition System FYI
Pre-1985 Polo's Ignition System FYI

Guest hypojam, 23 February, 200818 yr
- 5 replies
- 5.9k views
funkster

26 November, 201312 yr
084/085 4/5 Speed Gearbox Codes & Ratios
084/085 4/5 Speed Gearbox Codes & Ratios
grungeisdead, 13 June, 201016 yr
- 32 replies
- 19.7k views
Loud and Proud

22 September, 201312 yr
Engine Efficiency
Engine Efficiency

carver, 5 September, 200818 yr
- 18 replies
- 12.1k views
petegt1

11 September, 201313 yr
polo head torque settings
polo head torque settings
tarn polo, 10 June, 200818 yr
- 25 replies
- 73.3k views
Leoni

1 August, 201313 yr
Polo Part No. Request Post
Polo Part No. Request Post
Robin, 7 August, 200620 yr
- 167 replies
- 45.9k views
not_19_forever

21 June, 201313 yr
mk3 085 gearboxes suitable for LSD fitting
mk3 085 gearboxes suitable for LSD fitting

Nick_S, 7 March, 201313 yr
- 1 reply
- 1.8k views
Nick_S

4 April, 201313 yr

Followers

No registered users viewing this page.

2001 6n2 1.0 running ragged, no power, etc
2001 6n2 1.0 running ragged, no power, etc

z3chyd · 10 June, 201412 yr

Hi all, new guy here with quite an annoying problem with my polo. First off it's a 2001 Polo 1.0 mpi 5-speed. I start it, and it will idle fine for a few mins, then after driving about a minute or two, it will start to bog down and have no power whatsoever, sounding like its running on 3 clyinders and backfiring through the intake, resulting in me having to stop, restart the engine and somehow that makes it so I can start off again, only to have the same problem recur, especially once I slow dow
- 21 replies
- 4327 views
z3chyd

10 June, 201412 yr

Yeti

Saturday at 20:113 days
mk2 heater matrix replacement
mk2 heater matrix replacement

chopperoli · 5 November, 20187 yr

Leaky heater in Mk2. Is this a dashboard out job or can it all be done from the scuttle tray
- 5 replies
- 1553 views
chopperoli

5 November, 20187 yr

dvderlm

Saturday at 16:513 days
Central Locking & Electric Windows Problem - Common?
Central Locking & Electric Windows Problem - Common?

Racehunter · 29 November, 20196 yr

Firstly, my apologies as this problem is posted on another forum, however I am desperate to fix the issue. My son has recently purchased his first car, a 2007 MY 1.4 Polo 5 door with low miles and full history. It’s a really nice vehicle, and drives extremely well, so much so that it belies its age. Just one small mark to the rear N/S quarter panel for me to sort. Anyway, he decided that he 'needed' to have a replacement radio to allow for Apple Car Play, so purchased a head unit and
- 8 replies
- 10891 views
Racehunter

29 November, 20196 yr

LozMcAree

Friday at 13:294 days
6k remote central locking
6k remote central locking

Yeti · 5 September Sep 5

I've got a 1998 6K Polo Estate with central locking, and a (rotten) 2004 Mk2 Caddy with remote central locking. If I wanted to change the Estate to remote locking, what bits do I need off the Caddy? Am I right in thinking the receiver's on the central locking pump?
- 5 replies
- 131 views
Yeti

5 September Sep 5

Christian6N

6 September Sep 6
Is there anyone here who can diagnose problems with a Polo on their own?
Is there anyone here who can diagnose problems with a Polo on their own?

surprise · 1 September Sep 1

Hello, everyone! I’ve always been the type of person who, as soon as any warning light comes on in the dashboard, immediately takes my 2020 Polo to a repair shop. But last week, an “Engine Malfunction” warning appeared on the dashboard, and the nearest repair shop charges 90 euros just to connect a diagnostic tool. I thought that was way too expensive. A user on the forum suggested I try OBDocker. I was pretty skeptical at first, but I ended up downloading the app and connecting the adapter. In
- 4 replies
- 160 views
surprise

1 September Sep 1

Yeti

5 September Sep 5

99 topics in this forum

Recently Browsing 0

Important Information

Configure browser push notifications

Chrome (Android)

Chrome (Desktop)

Safari (iOS 16.4+)

Safari (macOS)

Edge (Android)

Edge (Desktop)

Firefox (Android)

Firefox (Desktop)