Notice: Support Requests - Going forward, all support requests will be handled via the forum. Please see the help section.

Engine, Transmission and Exhaust

Engine, Exhaust, ECU, Fuel system, Clutch, Gearbox, and Driveshafts.

Followers

DON'T GIVE OUT DUFF ADVICE. IF YOU DON'T KNOW THE ANSWER THEN DON'T ANSWER - SIMPLE!!!

Please be careful when answering peoples technical questions that you do not misguide them into taking inappropriate action. Not only is this annoying, but it can also be costly and could even be dangerous if the wrong information is given. This is why we ask that only first-hand and factual information is posted in reply to peoples queries. If you are not 100% certain of your reply, be sure to point out your uncertainty.

FAQ
FAQ

Contains Frequently Asked Questions relating to Engines, Transmission and Exhausts.
- 4.5k posts
information - mk2f GT tuning

mr brightside, 15 February Feb 15

Firing order 1.6 polo mk4
Firing order 1.6 polo mk4

stormtrooper, 31 July, 201412 yr
- 5 replies
- 6.4k views
nige8021

1 August, 201412 yr
1.4 (ABD) Golf > Polo GT Conversion
1.4 (ABD) Golf > Polo GT Conversion
Master_G, 18 June, 200818 yr
- 25 replies
- 6.4k views
MikeyMK

21 June, 200818 yr
Plug. -- the gap? Help & comments please.
Plug. -- the gap? Help & comments please.

jimk, 6 February, 201016 yr
- 2 replies
- 6.4k views
fonzooorooo

7 February, 201016 yr
Water Pipe From Housing To Pump
Water Pipe From Housing To Pump

chopper87, 21 July, 201214 yr
- 12 replies
- 6.4k views
EyeLid

30 June, 201610 yr
Polol 16valve timing marks
Polol 16valve timing marks

paulopolo, 9 May, 201016 yr
- 15 replies
- 6.4k views
paulopolo

19 May, 201016 yr
AKL upgrades
AKL upgrades

Ross74h, 19 August, 201115 yr
- 20 replies
- 6.4k views
BobProperty

26 February, 201214 yr
Diff Whine Noise
Diff Whine Noise
sc00byd00byd00, 7 July, 200917 yr
- 30 replies
- 6.4k views
Dean

11 October, 201213 yr
mk2 polo coupe s engine code MH says its a GT on the sticker in the boot?
mk2 polo coupe s engine code MH says its a GT on the sticker in the boot?

Guest geenius_gee, 12 October, 200916 yr
- 21 replies
- 6.4k views
Guest

27 October, 200916 yr
What mileage can the MK4 & MK5 1.4/1.4 16v engines do?
What mileage can the MK4 & MK5 1.4/1.4 16v engines do?

Kev_83, 29 July, 201016 yr
- 18 replies
- 6.3k views
raikky

2 August, 201016 yr
Diesel problems (1.9 SD AEF engine Lucas pump)
Diesel problems (1.9 SD AEF engine Lucas pump)

seamonsta, 4 November, 200817 yr
- 4 replies
- 6.3k views
seamonsta

4 November, 200817 yr
AFH, CBR600 Carbs, MK2 Ignition
AFH, CBR600 Carbs, MK2 Ignition
skapunk1, 11 December, 200916 yr
- 41 replies
- 6.3k views
skapunk1

22 December, 200916 yr
Where is the PCV valve located
Where is the PCV valve located

Guest blair205, 27 June, 200917 yr
- 3 replies
- 6.3k views
Guest

28 June, 200917 yr
Gearbox/Clutch dry bearing noise
Gearbox/Clutch dry bearing noise

alexc, 9 April, 20215 yr
- 6 replies
- 6.3k views
alexc

9 April, 20215 yr
1.8T engine swap into 9n3
1.8T engine swap into 9n3

pullen664, 24 July, 201610 yr
- 3 replies
- 6.3k views
nige8021

25 July, 201610 yr
Ah f*ckin sh*t...
Ah f*ckin sh*t...
DKnight, 28 August, 200719 yr
- 60 replies
- 6.3k views
DKnight

28 August, 200719 yr
R32 engine in a 6n polo
R32 engine in a 6n polo

Simple_Jim, 14 September, 201016 yr
- 13 replies
- 6.3k views
Simple_Jim

15 September, 201016 yr
Polo 6n2 Gti Camshaft Position Sensor
Polo 6n2 Gti Camshaft Position Sensor

darkartist_13, 31 July, 201214 yr
- 6 replies
- 6.3k views
darkartist_13

3 August, 201214 yr
head gasket gone on a mk2 polo
head gasket gone on a mk2 polo

brendanholdaway, 4 April, 201115 yr
- 9 replies
- 6.3k views
Yeti

19 April, 201115 yr
G40 engine or not G40 engine
G40 engine or not G40 engine
DougyG40, 29 December, 200718 yr
- 79 replies
- 6.3k views
Nick_S

9 January, 200818 yr
Spark Plug
Spark Plug

Evo_Ade, 26 October, 201213 yr
- 8 replies
- 6.3k views
g40dabbsy

29 October, 201213 yr
polo gti misfire , jerking, juddering
polo gti misfire , jerking, juddering

mista_khan, 11 April, 201115 yr
- 6 replies
- 6.2k views
kane3000

15 April, 201115 yr
megajolt vs standard ignition
megajolt vs standard ignition
dubownerbilco, 6 January, 201214 yr
- 43 replies
- 6.2k views
rallynav

10 January, 201214 yr
Engine options MK3 Polo
Engine options MK3 Polo
danielmi, 6 May, 200917 yr
- 29 replies
- 6.2k views
MikeyMK

8 May, 200917 yr
Raspy raspy
Raspy raspy
Sdub, 17 October, 201015 yr
- 72 replies
- 6.2k views
B-shaw

13 November, 201015 yr
EGR Valve fault - P0408 - Lack of power - HELP !
EGR Valve fault - P0408 - Lack of power - HELP !

DonnyPolo, 17 January, 20224 yr
- 10 replies
- 6.2k views
DonnyPolo

5 February, 20224 yr

Followers

No registered users viewing this page.

mk2 heater matrix replacement
mk2 heater matrix replacement

chopperoli · 5 November, 20187 yr

Leaky heater in Mk2. Is this a dashboard out job or can it all be done from the scuttle tray
- 7 replies
- 1565 views
chopperoli

5 November, 20187 yr

Yeti

57 minutes ago57 min
2001 6n2 1.0 running ragged, no power, etc
2001 6n2 1.0 running ragged, no power, etc

z3chyd · 10 June, 201412 yr

Hi all, new guy here with quite an annoying problem with my polo. First off it's a 2001 Polo 1.0 mpi 5-speed. I start it, and it will idle fine for a few mins, then after driving about a minute or two, it will start to bog down and have no power whatsoever, sounding like its running on 3 clyinders and backfiring through the intake, resulting in me having to stop, restart the engine and somehow that makes it so I can start off again, only to have the same problem recur, especially once I slow dow
- 21 replies
- 4333 views
z3chyd

10 June, 201412 yr

Yeti

Saturday at 20:114 days
Central Locking & Electric Windows Problem - Common?
Central Locking & Electric Windows Problem - Common?

Racehunter · 29 November, 20196 yr

Firstly, my apologies as this problem is posted on another forum, however I am desperate to fix the issue. My son has recently purchased his first car, a 2007 MY 1.4 Polo 5 door with low miles and full history. It’s a really nice vehicle, and drives extremely well, so much so that it belies its age. Just one small mark to the rear N/S quarter panel for me to sort. Anyway, he decided that he 'needed' to have a replacement radio to allow for Apple Car Play, so purchased a head unit and
- 8 replies
- 10898 views
Racehunter

29 November, 20196 yr

LozMcAree

Friday at 13:295 days
6k remote central locking
6k remote central locking

Yeti · 5 September Sep 5

I've got a 1998 6K Polo Estate with central locking, and a (rotten) 2004 Mk2 Caddy with remote central locking. If I wanted to change the Estate to remote locking, what bits do I need off the Caddy? Am I right in thinking the receiver's on the central locking pump?
- 5 replies
- 135 views
Yeti

5 September Sep 5

Christian6N

6 September Sep 6
Is there anyone here who can diagnose problems with a Polo on their own?
Is there anyone here who can diagnose problems with a Polo on their own?

surprise · 1 September Sep 1

Hello, everyone! I’ve always been the type of person who, as soon as any warning light comes on in the dashboard, immediately takes my 2020 Polo to a repair shop. But last week, an “Engine Malfunction” warning appeared on the dashboard, and the nearest repair shop charges 90 euros just to connect a diagnostic tool. I thought that was way too expensive. A user on the forum suggested I try OBDocker. I was pretty skeptical at first, but I ended up downloading the app and connecting the adapter. In
- 4 replies
- 164 views
surprise

1 September Sep 1

Yeti

5 September Sep 5

Subforums

31325 topics in this forum

Recently Browsing 0

Important Information

Configure browser push notifications

Chrome (Android)

Chrome (Desktop)

Safari (iOS 16.4+)

Safari (macOS)

Edge (Android)

Edge (Desktop)

Firefox (Android)

Firefox (Desktop)